Nubira-Lacetti
 Body Repair Manual
  0. SERVICE NOTICE
  1. GENERAL INFORMATION
  2. PREPARATIONS OF BODYWORK
  3. WELDING AND TOOLS
  4. FRONT
  5. ROOF, BACK PANEL AND REAR FLOOR PANEL
  6. FRAME DOOR OPENING, DOOR AND SIDE PANEL OUTER
  7. FENDER, HOOD, TAILGATE AND TRUNK LID
  8. BODY DIMENSION
  9. SEALING, CAULKING AND DEADNER
  10. RUST PREVENTION
  11. BODY-FRAME REPAIR EQUIPMENT
 Wiring Diagrams
 LHD
  1. HOW TO READ ELECTRICAL WIRING DIAGRAM
  2. POSITION OF CONNECTORS AND GROUNDS
  3. WIRING DIAGRAM FOR POWER SUPPLIES
  4. USAGE AND CAPACITY OF FUSES IN FUSE BLOCK
 5. ELECTRICAL WIRING DIAGRAMS
  1. STARTING & CHARGING SYSTEM
  2. ECM (ENGINE CONTROL MODULE) : MR - 140
  3. ECM (ENGINE CONTROL MODULE) : HV - 240
  4. ECM (ENGINE CONTROL MODULE) : SIRIUS D4
  5. TCM (TRANSMISSION CONTROL MODULE) : MR-140/HV-240
  6. TCM (TRANSMISSION CONTROL MODULE) : SIRIUS D4
  7. AIR CONDITIONER
  8. FATC (FULL AUTOMATIC TEMPERATURE CONTROL)
  9. RADIATOR COOLING FAN CIRCUIT
  10. HEAD LAMP & HEAD LAMP LEVELING DEVICE (HLLD) CIRCUIT
  11. DRL (DAY TIME RUNNING LIGHT) CIRCUIT
  12. ILLUMINATION CIRCUIT
  13. FRONT & REAR FOG LAMP CIRCUIT
  14. HAZARD & TURN SIGNAL LAMP CIRCUIT
  15. STOP LAMP, CENTER HIGH MOUNT STOP LAMP (CHMSL) & REVERSE LAMP CIRCUIT
  16. KEY INTERLOCK CIRCUIT : MEXICO
  17.TRUNK/TAIL GATE OPEN SWITCH, TRUNK LATCH SWITCH, TRUNK ROOM LAMP & HORN CIRCUIT
  18. LAMP (MAP & ROOM) CIRCUIT
  19. CLOCK, CIGAR LIGHTER, ASHTRAY ILLUM. LAMP, GLOVE BOX LAMP & EXTRA POWER JACK CIRCUIT
  20. WIPER CIRCUIT
  21. FRONT/REAR WINDOW DEFROSTER & OSRV MIRROR HEATING SYSTEM CIRCUIT
  22. ELECTRIC OSRV (OUTSIDE REAR VIEW) MIRROR CIRCUIT
  23. FOLDING MIRROR UNIT CIRCUIT
  24. POWER WINDOW CIRCUIT
  25. POWER WINDOW CIRCUIT
  26. CLUSTER
  27. CLUSTER
  28. ABS (ANTILOCK BRAKE SYSTEM)
  29. ABS (ANTILOCK BRAKE SYSTEM)
  30. SUN ROOF CIRCUIT
  31. SSPS (SPEED SENSITIVE POWER STEERING) CIRCUIT
  32. IMMOBILIZER SYSTEM CIRCUIT
  33. ANTI THEFT CONTROL SYSTEM CIRCUIT
  34. ANTI THEFT CONTROL SYSTEM CIRCUIT
  35. BATTERY SAVER CIRCUIT
 RHD
  1. HOW TO READ ELECTRICAL WIRING DIAGRAM
  2. POSITION OF CONNECTORS AND GROUNDS
  3. WIRING DIAGRAM FOR POWER SUPPLIES
  4. USAGE AND CAPACITY OF FUSES IN FUSE BLOCK
 5. ELECTRICAL WIRING DIAGRAMS
  1. STARTING & CHARGING SYSTEM
  2. ECM (ENGINE CONTROL MODULE) : MR - 140
  3. ECM (ENGINE CONTROL MODULE) : HV - 240
  4. ECM (ENGINE CONTROL MODULE) : SIRIUS D4
  5. TCM (TRANSMISSION CONTROL MODULE) : MR-140/HV-240
  6. TCM (TRANSMISSION CONTROL MODULE) : SIRIUS D4
  7. AIR CONDITIONER
  8. FATC (FULL AUTOMATIC TEMPERATURE CONTROL)
  9. RADIATOR COOLING FAN CIRCUIT
  10. HEAD LAMP & HEAD LAMP LEVELING DEVICE (HLLD) CIRCUIT
  11. ILLUMINATION CIRCUIT
  12. FRONT & REAR FOG LAMP CIRCUIT
  13. HAZARD & TURN SIGNAL LAMP CIRCUIT
  14. STOP LAMP, CENTER HIGH MOUNT STOP LAMP (CHMSL) & REVERSE LAMP CIRCUIT
  15.TRUNK/TAIL GATE OPEN SWITCH, TRUNK LATCH SWITCH, TRUNK ROOM LAMP & HORN CIRCUIT
  16. LAMP (MAP & ROOM) CIRCUIT
  17. CLOCK, CIGAR LIGHTER, ASHTRAY ILLUM. LAMP, GLOVE BOX LAMP & EXTRA POWER JACK CIRCUIT
  18. CHIME BELL, SEAT BELT & KEY REMIND SWITCH CIRCUIT
  19. WIPER CIRCUIT
  20. FRONT/REAR WINDOW DEFROSTER & OSRV MIRROR HEATING SYSTEM CIRCUIT
  21. ELECTRIC OSRV (OUTSIDE REAR VIEW) MIRROR CIRCUIT
  22. FOLDING MIRROR UNIT CIRCUIT
  23. POWER WINDOW CIRCUIT
  24. CENTRAL DOOR LOCKING SYSTEM CIRCUIT
  25. CLUSTER
  26. AUDIO CIRCUIT
  27. ABS (ANTILOCK BRAKE SYSTEM)
  28. AIR BAG (SDM: SENSING & DIAGNOSTIC MODULE) CIRCUIT
  29. SUN ROOF CIRCUIT
  30. SSPS (SPEED SENSITIVE POWER STEERING) CIRCUIT
  31. IMMOBILIZER SYSTEM CIRCUIT
  32. ANTI THEFT CONTROL SYSTEM CIRCUIT
  33. BATTERY SAVER CIRCUIT
 Labour Time Guide
  0. General Information
 1. Engine
  ENGINE (SOHC ENGINE MECHANICAL)
  ENGINE (DOHC ENGINE MECHANICAL)
  ENGINE (ENGINE COOLING)
  ENGINE (ENGINE ELECTRICAL)
  ENGINE (ENGINE CONTROLS)
  ENGINE (ENGINE INTAKE & EXHAUST)
 2. Suspension
  SUSPENSION (FRONT SUSPENSION)
  SUSPENSION (REAR SUSPENSION)
  SUSPENSION (TIRES & WHEEL)
  3. Driveline Axle
 4. Brakes
  (HYDRAULIC BRAKE)
  (MASTER CYLINDER & POWER BOOSTER)
  (FRONT BRAKES)
  (REAR BRAKES)
  (ANTI-LOCK BRAKES SYSTEM)
  (PARKING BRAKES)
 5. Transmissions/Transaxle
  (ZF 16HP AUTO TRANSAXLE)
  (AISIN AUTO TRANSAXLE)
  (FIVE-SPEED MANUAL TRANSAXLE: D16, D20)
  (FIVE-SPEED MANUAL TRANSAXLE: Y4M)
  (CLUTCH)
 6. Steering
  STEERING (POWER STEERING SYSTEM)
  STEERING (MANUAL STEERING GEAR)
  STEERING (STEERING WHEEL & COLUMN)
 7. (HVAC) Heating, Ventilation, and Air Conditioning
  HEATING & VENTILATION
  HVAC CONTROL
 8. Restraints
  RESTRAINTS (SEAT BELTS)
  RESTRAINTS S. I. R (SUPPLEMENTAL INFLATABLE RESTRAINTS)
 9. Body and Accessories
  (BODY WIRING SYSTEM)
  (LIGHTING SYSTEM)
  (WIPER/WASHER SYSTEM)
  (INSTRUMENT DRIVER SYSTEM)
  (AUDIO & ANTI-THEFT SYSTEM)
  (INTERIOR TRIM)
  (SEATS)
  (GLASS & MIRRORS)
  (EXTERIOR PARTS)
  (BUMPERS & FASCIAS)
  (DOORS)
  (ROOF)
  (BODY FRONT END)
  (BODY REAR END)
 10. Paint
  Paint
  Paint Exterior
 Pre-Delivery Inspection
  Foreword
  GENERAL INTRODUCTION
  ENGINE COMPARTMENT
  BODY - ACCESSORIES
  UNDER VEHICLE
  ROAD TEST
  APPEARANCE
  ANNEX
 Service Manual
  0. General Information
 1. Engine
  GENERAL ENGINE INFORMATION
  1.4L/1.6L DOHC ENGINE MECHANICAL
 1.8L - FAM I DOHC ENGINE MECHANICAL
  SPECIFICATIONS
  SPECIAL TOOLS
  COMPONENT LOCATOR
  MAINTENANCE AND REPAIR
  UNIT REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
  ENGINE COOLING
 ENGINE ELECTRICAL
  SPECIFICATIONS
  SCHEMATIC AND ROUTING DIAGRAMS
  DIAGNOSIS
  MAINTENANCE AND REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
 ENGINE CONTROLS
  SPECIFICATIONS
  SCHEMATIC AND ROUTING DIAGRAMS
  COMPONENT LOCATOR
 DIAGNOSIS
  SYSTEM DIAGNOSIS
  Diagnostic Aids
  Idle Learn Procedure
  TEC (TOOTH ERROR CORRECTION) Learn Procedure
  ON-Board Diagnostic (EOBD) System Check (1.4L/1.6L DOHC)
  ON-Board Diagnostic (EOBD) System Check (1.8D-FAM I)
  Multiple ECM Information Sensor DTCs Set
  Engine Cranks But Will Not Run (1.4L/1.6L DOHC)
  Engine Cranks But Will Not Run (1.8D-FAM I)
  No Malfunction Indicator Lamp (1.4L/1.6L DOHC)
  No Malfunction Indicator Lamp (1.8D-FAM I)
  Malfunction Indicator Lamp On Steady (1.4L/1.6L DOHC)
  Malfunction Indicator Lamp on Steady (1.8D-FAM I)
  Fuel System Diagnosis
  Fuel Pump Relay Circuit Check (1.4L/1.6L DOHC)
  Fuel Pump Relay Circuit Check (1.8D-FAM I)
  Main Relay Circuit Check (1.4L/1.6L DOHC)
  Main Relay Circuit Check (1.8D-FAM I)
  Manifold Absolute Pressure Check (1.4L/1.6L DOHC)
  Manifold Absolute Pressure Check (1.8D-FAM I)
  Idle Air Control System Check (1.4L/1.6L DOHC)
  Idle Air Control System Check (1.8D-FAM I)
  Ignition System Check (1.4L/1.6L DOHC)
  Ignition System Check (1.8D-FAM I)
  Engine Cooling Fan Circuit Check - Dual Fan (1.4L/1.6L DOHC)
  Engine Cooling Fan Circuit Check - Dual Fan (1.8D-FAM I)
  Data Link Connector Diagnosis (1.4L/1.6L DOHC)
  Data Link Connector Diagnosis (1.8D-FAM I)
  Fuel Injector Balance Test
 TROUBLE CODE DIAGNOSIS (1.4L/1.6L DOHC)
  Clearing Trouble Codes
  Diagnostic Trouble Codes (1.4L/1.6L DOHC)
 Diagnostic Trouble Code (DTC)
  P0030 H02S (Sensor 1) Heater Circuit Not Functioning
  P0036 H02S (Sensor 2) Heater Circuit Not Functioning
  P0107 Manifold Absolute Pressure Sensor Low Voltage
  P0108 Manifold Absolute Pressure Sensor High Voltage
  P0131 HO2S (Sensor 1) Low Voltage
  P0137 HO2S (Sensor 2) Low Voltage
  P0132 HO2S (Sensor 1) High Voltage
  P0138 HO2S (Sensor 2) High Voltage
  P0261 Injector 1 Low Voltage
  P0264 Injector 2 Low Voltage
  P0267 Injector 3 Low Voltage
  P0270 Injector 4 Low Voltage
  P0262 Injector 1 High Voltage
  P0265 Injector 2 High Voltage
  P0268 Injector 3 High Voltage
  P0271 Injector 4 High Voltage
  P0351 Ignition Control Circuit 1 and 4 Fault
  P0352 Ignition Control Circuit 2 and 3 Fault
  P0400 Exhaust Gas Recirculation Flow Out of Limit
  P0401 Exhaust Gas Recirculation Blocked
  P0444 EVAP Purge Control Circuit No Signal
  P0445 EVAP Purge Control Circuit Fault
  P0480 - Low Speed Cooling Fan Relay Circuit Fault
  P0481 - High Speed Cooling Fan Relay Circuit Fault
  P0601 - Engine Control Module Checksum Error
  P0604 - Engine Control Module RAM Error
  P0605 - Engine Control Module Write Error
  DTC P0112
  DTC P0113
  DTC P0117
  DTC P0118
  DTC P0122
  DTC P0123
  DTC P0133
  DTC P0140
  DTC P0171
  DTC P0172
  DTC P0222
  DTC P0223
  DTC P0300
  DTC P0327
  DTC P0335
  DTC P0336
  DTC P0337
  DTC P0341
  DTC P0342
  DTC P0403
  DTC P0404
  DTC P0405
  DTC P0406
  DTC P0420
  DTC P0462
  DTC P0463
  DTC P0501
  DTC P0510
  DTC P0562
  DTC P0563
  DTC P0628
  DTC P0629
  DTC P0646
  DTC P0647
  DTC P0650
  DTC P0656
  DTC P0661
  DTC P0662
  DTC P0700
  DTC P1390
  DTC P1396
  DTC P1504
  DTC P1610
  DTC P1611
  DTC P1628
  DTC P1629
  DTC P1650
  DTC P2101
  DTC P2118
  DTC P2119
  DTC U0101
 TROUBLE CODE DIAGNOSIS (1.8D-FAM I)
  Clearing Trouble Codes
  Diagnostic Trouble Codes (1.8D-FAM I)
  DTC P0016
  DTC P0106
  DTC P0107
  DTC P0108
  DTC P0112
  DTC P0113
  DTC P0117
  DTC P0118
  DTC P0122
  DTC P0123
  DTC P0131
  DTC P0132
  DTC P0133
  DTC P0134
  DTC P0135
  DTC P0137
  DTC P0138
  DTC P0140
  DTC P0141
  DTC P0171
  DTC P0172
  DTC P0201
  DTC P0202
  DTC P0203
  DTC P0204
  DTC P0300
  DTC P0315
  DTC P0317
  DTC P0324
  DTC P0325
  DTC P0335
  DTC P0336
  DTC P0340
  DTC P0351
  DTC P0352
  DTC P0401
  DTC P0402
  DTC P0404
  DTC P0405
  DTC P0406
  DTC P0420
  DTC P042E
  DTC P0443
  DTC P0461
  DTC P0462
  DTC P0463
  DTC P0502
  DTC P0506
  DTC P0507
  DTC P0532
  DTC P0533
  DTC P0562
  DTC P0563
  DTC P0601
  DTC P0602
  DTC P0606
  DTC P0660
  DTC P0700
  DTC P1133
  DTC P1134
  DTC P1166
  DTC P1391
  DTC P1392
  DTC P1393
  DTC P1396
  DTC P1397
  DTC P1631
  DTC P2297
  DTC P2610
  DTC U0101
  DTC U0167
  SYMPTOM DIAGNOSIS
  MAINTENANCE AND REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
  ENGINE EXHAUST
 2. Suspension
  SUSPENSION DIAGNOSIS
  WHEEL ALIGNMENT
  FRONT SUSPENSION
  REAR SUSPENSION
  TIRES AND WHEELS
 3. Driveline Axle
  AUTOMATIC TRANSAXLE DRIVE AXLE
  MANUAL TRANSAXLE DRIVE AXLE
 4. Brakes
  HYDRAULIC BRAKES
  MASTER CYLINDER
  POWER BOOSTER
  FRONT DISC BRAKES
  REAR DISC BRAKES
  REAR DRUM BRAKES
 ANTILOCK BRAKE SYSTEM
  SPECIFICATIONS
  SPECIAL TOOLS
  SCHEMATIC AND ROUTING DIAGRAMS
  COMPONENT LOCATOR
 DIAGNOSIS
  Diagnostic Circuit Check
  ABS Indicator Lamp Inoperative
  Power Supply to Control Module, No DTCs Stored
  ABS Indicator Lamp Illuminated Continuously, No DTCs Stored
  Electronic Brake-Force Distribution (EBD) System Indicator Lamp Inoperative
  Self-Diagnostics
  Displaying DTCs
  Clearing DTCs
  Intermittents and Poor Connections
  DTC C0035/C0036
  DTC C0040/C0041
  DTC C0045/C0046
  DTC C0050/C0051
  DTC C0060/C0065
  DTC C0070/C0075
  DTC C0080/C0085
  DTC C0090/C0095
  DTC C0110
  DTC C0121
  DTC C0141/C0146/C0151/C0156
  DTC C0161
  DTC C0550
  DTC C0800
  DTC C0931
  MAINTENANCE AND REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
  PARKING BRAKE
  5. Transmissions/Transaxle
 6. Steering
  POWER STEERING SYSTEM
  POWER STEERING PUMP
  POWER STEERING GEAR
  STEERING WHEEL AND COLUMN
 7. (HVAC) Heating, Ventilation, and Air Conditioning
  HEATING AND VENTILATION SYSTEM
 MANUAL CONTROL HEATING, VENTILATION AND AIR CONDITIONING SYSTEM
  SPECIFICATIONS
  SPECIAL TOOLS
  SCHEMATIC AND ROUTING DIAGRAMS
  DIAGNOSIS
  MAINTENANCE AND REPAIR
  UNIT REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
 AUTOMATIC TEMPERATURE CONTROL HEATING, VENTILATION, AND AIR CONDITIONING SYSTEM
  SPECIFICATIONS
  SCHEMATIC AND ROUTING DIAGRAMS
  DIAGNOSIS
  MAINTENANCE AND REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
 8. Restraints
  SEAT BELTS
 SUPPLEMENTAL INFLATABLE RESTRAINTS (SIR)
  SPECIFICATIONS
  SPECIAL TOOLS
  SCHEMATIC AND ROUTING DIAGRAMS
 DIAGNOSIS
  Diagnostic Trouble Code (DTC)
  Scan Tool Diagnostics
  SIR Diagnostic System Check
  Sensing and Diagnostic Module (SDM) Integrity check
  Diagnostic TIC Trouble Code (DTC) 1
  DTC 2
  DTC 3
  DTC 4
  DTC 5
  DTC 6
  DTC 7
  DTC 8
  DTC 9
  DTC 10
  DTC 11
  DTC 12
  DTC 13
  DTC 14
  DTC 15
  DTC 16
  DTC 23
  DTC 24
  DTC 25
  DTC 31
  DTC 32
  DTC 33
  DTC 34
  DTC 35
  DTC 38
  DTC 52
  DTC 53
  DTC 54
  DTC 55
  DTC 56
  DTC 57
  DTC 58
  DTC 59
  DTC 80
  DTC 81
  DTC 82
  DTC 83
  DTC 84
  DTC 85
  DTC 86
  DTC 87
  MAINTENANCE AND REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
 9. Body and Accessories
  BODY WIRING SYSTEM
 LIGHTING SYSTEMS
  SPECIFICATIONS
  SCHEMATIC AND ROUTING DIAGRAMS
  DIAGNOSIS
  MAINTENANCE AND REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
  HORN(S)
  WIPERS/WASHER SYSTEMS
 INSTRUMENTATION/DRIVER INFORMATION
  SPECIFICATIONS
  SCHEMATIC AND ROUTING DIAGRAMS
  DIAGNOSIS
  MAINTENANCE AND REPAIR
  GENERAL DESCRIPTION AND SYSTEM OPERATION
  AUDIO SYSTEMS
  INTERIOR TRIM
  SEATS
  WATERLEAKS
  WINDNOISE
  SQUEAKS AND RATTLES
  GLASS AND MIRRORS
  EXTERIOR TRIM
  FRAME AND UNDERBODY
  BUMPERS AND FASCIAS
  DOORS
  ROOF
  BODY FRONT END
  BODY REAR END
  REMOTE KEYLESS ENTRY AND ANTI-THEFT SYSTEM
  IMMOBILIZER ANTI-THEFT SYSTEM

www.inocats.com Удаленный доступ к автокаталогам
  Яндекс.Метрика